1787-USADPTR现货 in stock! 欢迎来电咨询~！！

　　在现代制药工业的生产过程中，不可避免地要使用大量的化学与生物制剂，这带来的一个结果是在生产的每个步骤都会排放出成分复杂的尾气，以挥发性有机化合物(VOC)居多。如何处理含VOC的尾气，成为企业面临的一大环保难题。国内目前主要采用热氧化法的处理方式，即蓄热式热力焚化炉(英文名为“Regenerative Thermal Oxidizer”，简称为“RTO”)
　　二、RTO工作原理
　　把有机废气加热到760摄氏度以上，使废气中的VOC在氧化分解成二氧化碳和水。废气首先通过蓄热体加热到接近热氧化温度，而后进入燃烧室进行热氧化，氧化后的气体温度升高，有机物基本上转化成二氧化碳和水。净化后的气体，经过另一蓄热体，温度下降，达到排放标准后排放。不同蓄热体之间通过切换阀，随时间进行转换，分别进行吸热和放热。氧化产生的高温气体流经特制的陶瓷蓄热体，使陶瓷体升温而“蓄热”，此“蓄热”用于预热后续进入的有机废气，从而节省废气升温的燃料消耗。陶瓷蓄热体应分成两个(含两个)以上的区或室，每个蓄热室依次经历蓄热-放热-清扫等程序，周而复始，连续工作。蓄热室“放热”后应立即通过反吹风机对该蓄热室进行清扫(以保证VOC去除率在95%以上)，只有待清扫完成后才能进入“蓄热”程序。RTO设备的工作流程见下图：
　三、控制要求和方法
　　3.1. 燃烧器控制
　　氧化室安装一个带比例调节的天然气燃烧器。燃烧器的供热量是用氧化室温度，经过PID调节器自动调节，当燃烧器运行时，燃烧器PID的SP外给定值(TE05_AM)等于SP外给定值+升温速率设定值/120。按照升温曲线进行升温。否则，SP外给定值等于氧化室温度。如果SP外给定值超过TE05_S10(氧化室温度--理想控制温度设定)，那么TE05_S10直接赋值给TE05_AM(SP外给定值)，进行温度限制。此外，燃烧系统还带有熄火保护、超温报警和超温自动停燃烧器等功能。
3.2.进气、出气、清扫流程的切换
　　该设备有三个蓄热室，一个公共氧化室，有机废气通过鼓风机送入蓄热室1，吸热后进入氧化室，蓄热室1因放热而降温，燃烧升温后的气体进入蓄热室2，通过热交换把热量蓄存在蓄热室2的陶瓷蓄热体中，处理后的气体经后续处理合格后烟囱排空。同时蓄热室3空间中残留未处理的VOC废气被反吹风机吹回氧化室焚化处理。经过一段时间(约2分钟(可设定))后，气流改变方向从蓄热室2进入氧化室，通过蓄热室2吸收热量升温后，在氧化室内高温焚化，最后经蓄热室3热交换后排放，同时蓄热室1处于清扫状态，经过一段时间(约2分钟(可设定))后，气流再次改变方向，不断的交替循环，保证氧化室温度在800℃以上，以此保证高的去除率和换热效率。程序如下图：

Reliance Electric Analog Input Module 57C409 factory

GSM/GPRS Modem Pool 8 Ports USB interface Wavecom Module AT Commands Q2406

NM-2V= CISCO Two Voice/Fax interface card slot network module spare / 30 d Wty

Yaskawa Memocon GL120 DDSCR-120CPU34100 Ver. FOB14 CPU20 120 CPU 341 00

Under valid Lenovo factory until 2015-03-31

Siemens LOGO! DM8 230R 6ED1 055-1FB00-0BA1 Module NIB

Siemens TP270 6AV6545-0CC10-0AX0 Touchscreen HMI

Schneider Modicon TSX Compact AS-BDAP-217 Discrete Output True Low

Schneider Modicon AS-BDAP-217 OUTPUT GUARANTEED ASBDAP217

Schneider Modicon AS-B821-108 USPP ASB821108

Schneider Modicon -AS-2802-000

Schneider Modicon AS-P933-007 Controller P5-984B-964 with Cards

Schneider Modicon AS-BDEP-216 Input Module 16-Point -

Schneider Telemecanique XBTGT2130 Opt Interface Panel

SIEMENS 6ES7 131-4EB00-0AB0 5 INPUT MODULE 2-POINT 120VAC 15MM

RVSI Siemens CiMatrix VisionScape Machine Vision System NICE

Siemens Digital Output Module 6ES5456-4UA12

SIEMENS SINUMERIK 820 T 6EW1861-3BA TESTED WARRANTY

Schneider Telemecanique AS-1 Communication Module ASILUFC5

SIEMENS 6SN1161-1CA00-0BA1 18 PIN DRIVE BUS CABLE

SIEMENS 6SC6101-2A-Z 6SC6101-2A SIMODRIVE 610 Transistor PWM Converters Chassis

SIEMENS 6FC5-111-0CA73-0AA1 USPP 6FC51110CA730AA1

AllenBradley7300-UDB3ServoOutputModule

ALLEN BRADLEY W51 NSFP W51

ABB DSQC266C 3HAB-8798-1/2B

ADTEC AX2000EU, 2000 watt 13.56Mhz RF Generator, looks rebuilt in OEM

(E11) 1 SIEMENS 3VF62115BM340AA0 CIRCUIT BREAKER (E11)

JOFRA INSTRUMENTS ATC320B115BM04ACG NSFP ATC320B115BM04AC

ACCURAY 082157-002 NSPP 082157002

FISHER ROSEMOUNT 9150-027-591 USPP 9150027591

FANUC A05B-2005-C050 USPP A05B2005C050

RUSSELL STOLL ELSFH8414FDC NSPP ELSFH8414FDC

POWERTEC INDUSTRIAL MOTORS INC A18CMJ1000800000 USPP A18CMJ1000800000

RELIANCE ELECTRIC 410403-51AW FNFP 41040351AW

Siemens 6ES5 458-7LA11 6ES54587LA11

Siemens 6ES5-926-3SA12 USPP 6ES59263SA12

SIEMENS 6ES5-430-4UA13 NSFP 6ES54304UA13

Siemens 6ES5 465-3AA13 6ES5465-3AA13 6ES54653AA13

Siemens S5 6ES5 451-7LA12

Siemens 7SJ6001-6EA00-1DA0/BB

Siemens 6ES7 322-1BL00-0AA0 -- 6ES73221BL000AA0

Square D 8003 FCB-54

NIB TELEMECANIQUE LA4DFB INTERFACE MODULE 24V

WS-SUP720-3BXL 1 WS-X6708-10G-3C Super Cisco Bundle

Siemens 6ES7 972-0CA23-0XA0 6ES79720CA230XA0 NIB

Siemens S7-200 EM231 6ES7 231-7PD21-0XB0 EM 231

Reliance 45C42

Schneider Modicon GouldAutomation AS-506P-004 Board

Schneider Modicon AS-B351-001 INPUT MODULE

Schneider Modicon AS-S902-141 USPP ASS902141

Schneider Modicon AS-B875-012 Analog Input Module UN OLD STOCK

Schneider Modicon AS-B805-016 Input Module 16POINT 115VAC

Modicon B804 16 Point Output Module Analog

SIEMENS PTM6.2P1K ANALOG INPUT MODULE

Siemens 6ES5 460-4UA13 -FS- 6ES54604UA13

SIEMENS RELAY OUTPUT MODULE 6ES5 451-7LA11 IN BOX

SIEMENS 6FX1118-8AC01 Sinumerik 3G _570 025 9030 00

Westinghouse NL1075B COMMUNICATIONS ADAPTER PLC MODULE

SIEMENS 6SN1118-0AE11-0AA0 6SN11180AE11OAAO 462008.1003.01 6SN11180AE110AA0

SIEMENS Simodrive 611 6SN1118-1NH00-0AA2 6SN1 118

SIEMENS 6FC5510-0BA00-0AA0 6FC5511-0CA00-0AA0 Free Ship

Advantech PCA-6278 PCA-6278V

Allen-Bradley 1771-0BD 10 To 60 VDC Output Module

ABB ASEA CIRCUIT BOARD CARD DSMB127 DSMB 127 OH 57360001-HG/2 2668 184-584/2

Adept Control MV-8 30330-15000 8-S Controller Rack 100/120V 200/240V WOW

6SE7027-2TP50 SIEMENS COMPACT + MASTERDRIVE 72AMP 37kW 510-620VDC MOTION CONTROL

HITACHI BASIC-H NSFP BASICH

SYMAX 8020-SCP-644 USPP 8020SCP644

CUTLER HAMMER NS360900A USPP NS360900A

COGNEX 800-5870-1 USPP 80058701

NIKKI DENSO NPSA-ZMTA-201AE USPP NPSAZMTA201AE

MITSUBISHI HC-H453S-A42 NSFP HCH453SA42

GE FANUC IC3606SIIE91 USPP IC3606SIIE91

Siemens 6ES5 246-4UA41 Free Shipping Worldwide

Siemens 6ES5-475-5AA11 NSFP 6ES54755AA11

SIEMENS 6ES5-308-3UB11/6ES5308-3UB11 INTERFACE MODULE XLNT

SIEMENS S5-100U 6ES5 931-8MD11

Siemens 6ES5 451-8MR12 Relay Output 8x30 VDC / 230VAC 6883

Siemens 6FC5410-0AY03-1AA0 CPU810D CCV3.4

Siemens TP170B 6AV6545-0BB15-2AX0 Touchscreen Glass

Siemens 6ES5453-8MA11

Juniper Avaya TIM521 BRI Telephony Interface Module 90 Day warranty Free Ship

ZigBee Module -RS232 Debug interface CC2530F256 Chip

Siemens 6ES7 211-0BA22-0XB0 6ES7211-0BA22-0XB0

Siemens OP177B 6AV6 642-0DA01-1AX0 Membrane Keypad

Phoenix Digital 0405-6300G3

Schneider Modicon AS-B872-002 Output Module B16

Schneider Modicon AS-584A-038 USPP AS584A038

Schneider Modicon AS-M680-108 NSPP ASM680108

Schneider Modicon AS-9490-022 Module Memory Card Lot of 6

Schneider Modicon 884 CONTROLLER AS-884A-100

Schneider Modicon TSX COMPACT HIGH SPEED COUNTER MODULE AS BZAE 201

Siemens TI 32 Pt. AC Input Module 500-5005

Telemecanique ATV31HU30N4A ATV31 3KW/3HP 380/500V

SIEMENS SIMATIC SM332 6ES7 332-5HD01-0AB0 ANALOG OUTPUT MODULE 2 CONNECTORS

Siemens 411 Operator Pnel Mounting Kit

SIEMENS SINUMERIK 840D 6FC5210-0DA00-0AA0/0AA1

C200H-ASC02 Omron PLC ASCII Basic Communication Module C200HASC02

SIEMENS SIMODRIVE 6SN1145-1AA01-0AA1SINUMETIK 840D NCU-BOX 6FC52476FC5356#2AA

SIEMENS SERVO DRIVE 6FC5247-0AA00-0AA3

Advantech PCA-6186VE PCA-6186 Rev.B2 NIB

Allen-Bradley 2711-T6C15L1 Panelview 600

ABB 3HNM 01868-1 Hollow Wrist Attachment TR 5002

ACCURAY OPERATOR CONTROL STATION INTERFACE ASSEMBLY W/ MONITOR + CONTROLS 57850

A30P3CDR-P US THREE PHASE MOTORS REMANUFACTURED

82kw (110hp) Permanent Magnet Electric Motor Perfect for EV Conversion PM DC

SIEMENS 6ES7-647-4DD20-3JX0 NSFP 6ES76474DD203JX0

ASEA BROWN BOVERI DCF504-0050 USPP DCF5040050

AMK AW20/30 USPP AW2030

MICROSTAR LABORATORIES DAP3200A/415 USPP DAP3200A415

IAI IS-M-X-M-10-100-300 USPP ISMXM10100300

ALLEN BRADLEY 1784-PCMK/B NSPP 1784PCMKB

SIEMENS 6ES7-422-5EH10-0AB0 USPP 6ES74225EH100AB0

Siemens 6ES5-405-7AA21 USPP 6ES54057AA21

SIEMENS 6ES5 458-7LA11 RELAY OUTPUT MODULE

SIEMENS 6ES5 482-7LA11 6ES5482-7LA11

Siemens PLC 6ES5-700-2LA12/6ES57002LA12 Sub Rack

Siemens 6ES7 331-7NF10-0AB0 6ES7331-7NF10-0AB0 NIB FS

Siemens PLC 6GK1 105-2AB10 NIB

PVDM3-256 CISCO 256-CHANNEL HIGH-DENSITY VOICE AND VIDEO DSP MODULE

H3C 0231A44C S7500 4port 10GE Interface Module w/ XGB

UNICO INC. 309-482 CPU SERIAL INTERFACE MODULE 309482

Siemens 6AV6 642-0DC01-1AX0 OP177B Membrane Keypad

Siemens LOGO 230RCL 6ED1 053-1FB00-0BA2

Nematron KBD-1002

Schneider Modicon Compact AS-BDAP-216 ASBDAP216 DC Output NIB

Schneider Modicon Circuit Board AS-516P-007 _ AS516P007

Schneider Modicon AS-E685-914 USPP ASE685914

Schneider Modicon GOULD AS-B872-002 MODULE ASB872002

Schneider Modicon AS-B806-032

Schneider Modicon P190 AS-P190-112 PLC Front Cover

Schneider/Modicon 140CPS11420 CPS11420

Schneider MODICON TXBTF024411F TXB TF024411F

SIEMENSSCD1597-IT1LCDMONITOR15"

Siemens 6AV6640-0CA11-0AX1 6AV6 640-0CA11-0AX1 SIMATIC TP177 Micro Touch

SIEMENS SIMADYN D 6DD3440-0AB2 6DD3470-0AC0 SW20 MS47 QUANTITY!!

GE Fanuc IC697CMM711Q Communications Coprocessor Module H7 852

SIEMENS SIMODRIVE POSMO A 300W 6SN21S5-2BD10-1BA1

SIEMENS SINUMERIK 6FC5203-0AF00-0AA1 Membrane Keypad- OP010 0P010free ship

SIEMENS MOORE 39IDM115ACCAN APACS QUADLOG IDM INPUT DISCRETE MODULE ROM V3 24999

Allen-Bradley Pane/View 300 Micro

AB 1336T-B050-AN-GT0 Ser.D 480V 61KVA 50HP PARTS

ABB-IRB660/180/3.15-IRC5 Palletizing robot - ABB - FANUC - MOTOMAN - NACHI

A06B-0346-B255 FANUC SERVO MOTORS

75 HP ELECTRIC MOTOR 1800 365TP VHS FOR IRRIGATION Replacement For US & GE

RELIANCE ELECTRIC 78469-R USPP 78469R

ALLEN BRADLEY 2711-K9A2 USPP 2711K9A2

ALLEN BRADLEY 1771-IR NSFP 1771IR

HONEYWELL 51196885-100 NSFP 51196885100

WESTINGHOUSE NB3800PF NSFP NB3800PF

THK GL15S16-1250L-C NSFP GL15S161250LC

GENERAL ELECTRIC DS3800NTCA USPP DS3800NTCA

Siemens 6ES5-188-3UA21 USPP 6ES51883UA21

SIEMENS 6ES5 375-0LC41 MEMORY MODULE

SIEMENS 6ES5-998-0SH21 NSPP 6ES59980SH21

Siemens 6ES5 942-7UA12/6ES59427UA12 CPU NICE

SIEMENS 6ES5-095-8MA02 6ES5095-8MA02 CPU

Siemens Micromaster 6SE6 400-0AP00-0AB0 Advanced Operator Panel

RELIANCE ELECTRIC 57C-433 USPP 57C433

Texas Instruments 500-5001

Spirent Adtech AX/4000 401383 OC3c/12c L3 MM Interface

VEXTA Fine Step 5-Phase Driver DFR1507 ONTEC ONTEC SAVE NET I/O MODULE

Siemens C98043-A1660-L1

Modicon AS-W511-002

Schneider Modicon AUTOMATION AS-BDAP-218 OUTPUT MODULE

Schneider Modicon 4 Channel Analog Input AS-BADU-205

Schneider Modicon AS-BDAP-209 IN BOX

Schneider Modicon AS-B872-100

Schneider Modicon SECONDARY SUBRACK AS HDTA 201

Schneider Modicon Auxiliary Power Supply AS-P120-000 WARRANTY

Schneider Modicon 140-NOE-771-00 140NOE77100

Scientific Atlanta Prisma DT Chassis Modules Decoders Optical Input

RELEASE SuperMicro X9DRH-IF MB ※FULL MFR ※

Siemens 6ES7 132-4BB31-0AA0 OUTPUT MODULE 2POINT 2AMP 24VDC

SIEMENS SINUMERIK 840D/DE NCU 573.3 6FC5357-0BB33-0AE2 NIB

MODICON PLC AS-J892-001 COMMUNICATION MODULE

SIEMENS SIMODRIVE 611 BOARD 6SN1118-0DJ23-0AA1

SIEMENS SINUMERIK OP 010 10.4" 6FC5203-0AF00-0AA1

SIEMENS CAT CATERPILLAR D6H TRACTOR SHOP REPAIR SERVICE MANUAL S/N 1KD 2KD 3ED 4RC 6FC

AllenBradley1756-OF6CI/A1756-0F6CIControlLogixOutputModuleCard

Allen Bradley SLC 500 Output Module 1746-OW16 Ser C White Label

ABB Robot IRB 1400 Welding Robot w/ S4 M94A Control, Teach Pendant, Hobart Pwr S

A06B-0128-B677#7208 FANUC SERVO MOTORS REMANUFACTURED

0.1-716 μm LPA-9S Desktop Fully Automatic Laser Particle Size Analyzer Sizer

MODICON AS-P230-080 USPP ASP230080

ALLEN BRADLEY 150-A135NBD USPP 150A135NBD

ADEPT TECH 10332-48712 USPP 1033248712

GE FANUC IC697CMM742 USPP IC697CMM742

SIEMENS S30810-Q2168-X/07 USPP S30810Q2168X07

SIEMENS 6ES5-955-3NF42 USPP 6ES59553NF42

ALLEN BRADLEY 5130-RM1 USPP 5130RM1

Siemens 6ES5 935-8ME11 6ES59358ME11

Siemens simatic 6es5244-3aa22 6es5 244-3aa22 XLT

SIEMENS 6ES5-521-8MA11 NSFP 6ES55218MA11

Siemens 6ES5 441-7LA13/6ES54417LA13 Output SEALED OFFERS ACCEPTED

SIEMENS 220uF 450V Capacitor 36 x 36mm

Siemens EM277 6ES7 277-0AA22-0XA0 6ES72770AA220XA0 NIB

Schneider 140DAI54300 Input Module

Square D 9050 PDH-11AA

SIEMENS 6GK1-502-3CB10 INTERFACE MODULE 6GK15023CB10

WE SHIP SAME CISCO SGE2000P CISCO 24PORT GB 4SFP STACKABLE SWIT

Siemens 6SA8252-0BC60 CU4

Siemens TP27-10 6AV3627-1QL01-0AX0 Touchscreen Glass

Schneider Modicon TSX COMPACT DIS INPUT MOD DEP 218 / AS-BDEP-218 5

Schneider Modicon AS-BDAP-209 Discreet Output Relay ASBDAP209

Schneider Modicon AS-B826-000 USPP ASB826000

Schneider Modicon AS-B805-016

Schneider Modicon AS-W600-006 USPP ASW600006

Schneider Modicon AS-C916-100 CPU Module Rev A12 UEX

SCHNEIDER TC2000 INDUSTRIAL PC OPERATOR INTERFACE 3515 KPM BROKEN NOB

SIEMENS 6ES5-921-3WB14 INPUT MODULE 6ES59213WB14

RSP720-3C-GE Cisco Route Switch Processor 720-3C Router

Siemens Cutout for OP17 Operator Panel Cut Out

SIEMENS Sinumerik 840C CRT MONITOR #6FC5103-0AB13-0AA2

Rotec VCOM4 Communication Module VMEbus

SIEMENS 6SN1-162-0EB00-0BA0 USPP 6SN11620EB000BA0

SIEMENS 6RB2160-0FB00 6RB2160-OFB00 6RB216O-OFBOO 6RB2 160-0FB00 SIMODRIVE Board

SIEMENS 6FC5-111-0CA01-0AA0 USPP 6FC51110CA010AA0

AllenBradley6180-FMMFHLHTHEN/BIndustrialComputer12"ColorKeypad/Touch

ALLEN BRADLEY VERSAVIEW CE 6182H-12TRH4D 6182H12TRH4D

ABB E6H-A-40 POWER DISTRIBUTION LOW VOLTAGE CIRCUIT BREAKER 4000A B223835

Adtran OPTI-6100 W SCM,DS1VME,DS1M,OMM12R,DS1VM,TRAM3C modules

(H3-1) 1 ALLEN BRADLEY 2711-T10G8L1 PANEL VIEW H3-1

KEYENCE CORP LS-5121 USPP LS5121