1747-L20B现货 in stock! 欢迎来电咨询~！！

国内的包装生产线在发展初期一般只能完成物料包装，后续的搬运工作则由搬运工人来完成。随着产量的日益扩大，传统的人工搬运方式显然无法满足需求，码垛机械的出现为这一问题提供了有效的解决方案。
　　码垛机可以集成在生产线中，使生产现场变得智能化，可以实现饮料、食品、日化等行业各种作业的码垛物流，为企业改善工作条件，减轻个人体力劳动，减员增效起到了关键作用。目前主流的控制系统采用 PLC+ 机械手的方式，对整条生产线的末端产品进行整理、堆叠、整垛输出等。
　　目前市场上主流的码垛线为单线输送系统，码垛能力在 30~40 箱 / 分，具体的码垛能力视货物而异。本项目中设计的码垛线为双线输送，码垛能力能达到 60 箱 / 分，主要应用在食品行业。该码垛线通过 PLC 控制将两条生产线上输送过的产品分别输送到对应的堆叠区，且通过触摸屏可设定不同的层数采用不同的堆叠方式，如第 1 层按方式 1 堆叠，第 2 层按方式 2 堆叠，码垛方式灵活。
　　2 工艺要求
　　码垛线分为 A、B 两线，每条线均由以下部分组成：入口输送带 1、入口输送带 2、入口输送带 3、分离电机、转向电磁阀、转向滚筒、堆叠输送带，出口输送带等;A、 B 两线共用栈板供应系统和左右栈板输送带等设备。码垛线装备实物图片如图 1 所示。
货物由入口输送带1进入，经过三个入口缓存输送带，输送到分离电机处;分离电机分离后根据需要确认是否转向 ( 如需转向则转向气缸动作 ) 并计数，PLC 进行判断产品是否已完成一列。达到一列后控制推杆动作，将货物整平。此时，PLC 发出 DO 信号给 ABB 机械手 (ABB 机械手与 PLC 通过硬接线连接 )，机械手动作抓取已完成码垛的一列产品;当完成一垛后，堆叠电机动作，将已完成堆垛的货物整垛输出;然后栈板供应启动，为缺少栈板的堆叠区提供栈板，依次循环实现持续码垛。其工艺流程如图 2 所示。
　3 自动化平台选型
　　鉴于该码垛机 I/O 点数较多 (DI 为 75，DO 为 40)，以及电控柜空间限制的需求，在系统选型时采用西门子 S7-200 SMART PLC 作为主控制器，因为 S7-200 SMART 具备 60I/O 的大点数 CPU 以及高密度扩展模块，并且模块体积紧凑，能够有效满足以上需求。码垛线上的转向气缸、滚筒等动作频繁，高达 20~30 次 / 分，故采用晶体管输出类型，外接中间继电器驱动大负载。在HMI选型上，单线系统选用7寸屏即能满足要求，但对于双线控制系统，需要显示的信息更多，最终选用 10 寸屏。同时，屏上集成的以太网接口与 S7-200 SMART 无缝连接，编程调试、设备通讯都很方便。电控系统配置如附表所示。
4.1 结构化模块设计
　　由于码垛线控制点数较多，程序较大，而且各部分功能较为分明，所以在软件设计时，采用结构化编程的理念可使程序结构更加分明。程序设计分为主程序和子程序两部分，主程序中 AB 两线运行各自调用相应子程序。子程序主要有：开机初始化程序、各设备手动控制程序、入口计数子程序、整列推杆初始化子程序、自动运行子程序、堆叠方式处理子程序、故障报警子程序、系统复位及数量清零等子程序组成，如图 3 所示。

COGNEX 800-5838-4 NSPP 80058384

ALLEN BRADLEY 2727-G7P20D1Q6 USPP 2727G7P20D1Q6

FANUC A02B-0094-C041 USPP A02B0094C041

ROBERTSHAW DMS-3501 USPP DMS3501

POLYSONICS DCT6088 USPP DCT6088

RELIANCE ELECTRIC 0-51890-3 USPP 0518903

Siemens 6ES5 456-7LA11 DIGITAL OUTPUT

Siemens 6ES5-926-3KU12 USPP 6ES59263KU12

SIEMENS 6ES5-430-4UA12 NSFP 6ES54304UA12

Siemens 6ES5 460-7LA13 Analog Input 6ES5460-7LA13

Siemens S5 6ES5 441-8MA11 8x24V DIGITAL OUTPUT

Siemens 7MF4033-1DA00-1AA6-Z Pressure Transmitter

Siemens 6ES7 322-1EH01-0AA0 -FS- 6ES73221EH010AA0

Square D 8003 CP-32

NIB Nematron IWS-102 IWS102 Operator Interface Panel Module Computer 24v

WS-SUP720-3BXL Cisco Supervisor Engine 720-3BXL Control processor

Siemens 6ES7 972-0BB41-0XA0 6ES7972-0BB41-0XA0 NIB

Siemens S7-200 EM231 6ES7 231-0HC20-0XA0 EM 231

Reliance 45C340

Schneider Modicon GOULD REMOTE I/O RECEIVER MODEL AS-J821-001

Schneider Modicon AS-B350-001 OUTPUT MODULE B350 115 VOLT AC

Schneider Modicon AS-S902-101 USPP ASS902101

Schneider Modicon AS-B873-011

Schneider Modicon AS-B805-016 B805 115 VAC INPUT

Modicon Controller Part AS-P464

SIEMENS S5 6ES5 421-8MA11 Digital Input Module8DI 24V

Siemens 6ES5 464-8MC11 -FS- 6ES54648MC11

Siemens RS 485-REPEATER 6ES7-972-0AA00-0XA0

SIEMENS 6FC5357-0BB21-0AE0 DRIVE SINUMERIK 840D/E2 NCU 572.2 VERSION A

WV Communications 19" 3 module Chassis

SIEMENS 6SN1118-0AD11-0AA0 6SN11180AD110AA0

SIEMENS SIMODRIVE 611 6SN1123-1AA00-0CA2 POWER MODULE 6SN11231AA000CA2 (NIB)

SIEMENS 6FC5510-0BA00-0AA0 USPP 6FC55100BA000AA0

Advantech PCA-6186VE PCA-6186 Rev.A1 NIB

Allen-Bradley 1771-OA AC OUTPUT MODULE

ABB ASEA BROWN BOVERI POWER ITE AIR CIRCUIT BREAKER 800A 800 AMP KDON K-DON 800S

ADEPT 90400-60131 AMPLIFIER MODULE MEGATORQUE 300 WATT CONTROLLER

6SE7026-0TP50 SIEMENS COMPACT + MASTERDRIVE 59AMP 30kW 510-620VDC MOTION CNTRL

SYMAX 8020-SCP-424 NSPP 8020SCP424

CUTLER HAMMER IDT0286 NSFP IDT0286

CLEVELAND MOTION CONTROL BNR5110GPA00CS0002 NSPP BNR5110GPAOOCS00

NEMATRON CORP IWS-4824 USPP IWS4824

MITSUBISHI FR-A520-2.2K-NA USPP FRA52022KNA

GE FANUC 44A719348-102 USPP 44A719348102

Siemens 6ES5 246-4UA11 6ES52464UA11

Siemens 6ES5-470-8MB11 NSFP 6ES54708MB11

SIEMENS 6ES5-306-7LA11 NSPP 6ES53067LA11

SIEMENS S5 SERIAL INTERFACE 6ES5 521-8MA21

Siemens 6ES5 441-8MA11 6ES54418MA11

SIEMENS 6FC5203-0AF50-3AA1 6FC5 203-0AF50-3AA1 MCP416C

Siemens TP170B 6AV6545-0BB15-2AX0 6AV6 545-0BB15-2AX0 Seal Opened FreeShip

Siemens 6ES5451-8MD11

Jova Solutions TIMS-0102 USB 12C/SPI Interface Module

ZARAK ABACUS BCG 81-01512-02 MODULE w/ ABACUS BRA Circuit Interface

Siemens 6ES7 210-8XX00-6AA0 6ES7210-8XX00-6AA0 PDS210 in Box, Seal opened

Siemens OP17 6AV3617-1JC20-0AX1 Membrane Keypad , ping worldwide

Patriot WA0750

Schneider Modicon AS-B872-002/ASB872002 Output Module OFFERS ACCEPTED

Schneider Modicon AS-5540-006 NSFP AS5540006

Schneider Modicon AS-M680-108 Memory Module

Schneider Modicon AS-9490-004 USPP AS9490004

Schneider Modicon 800 SERIES 11 SLOT RACK AS-H827-103

Schneider Modicon TSX COMPACT DISCRETE INPUT DEP 216 AS-BDEP-216 LOT OF 5

Siemens TI 505-4108 Low VDC Input Module

Telemecanique ATV11HU09M3A 0.37kW Inverter in Box

SIEMENS SIMATIC SM422 DIGITAL OUTPUT MODULE S7-400 ++

SIEMENS 4700 POWER FUNCTIONS METER OPERATOR INTERFACE PANEL 4700-BDRMC3-11HN

SIEMENS Sinumerik 840C/840CE P/Supp 6FC5114-0AA01-1AA0

CC LINK COMMUNICATIONS MODULE MITSUBISHI FR-E5NC

SIEMENS SIMODRIVE 6SN1145-1AA01-0AA1SINUMETIK 840D NCU-BOX 6FC52476FC5357 6SN

SIEMENS Servo Drive 6FC5247-0AA00-0AA3 6FC52470AA000AA3

Advantech PCA-6184V, no ethernet port,

Allen-Bradley 2711-T6C15L1 Panelview 600

ABB 3HNE00313-1

ACCURAY AIC8 086155-001 SCANNER MODULE CARD CONTROLLER B211850

A2LA 17025 Accredited Calibration with full Data Report

82-1/2" OVER ALL LENGTH 2-1/4" DIAMETER BALLSCREW 55" TRAVEL 5-1/2" FLANGE

SIEMENS 6ES7-623-1DE01-0AE3 USPP 6ES76231DE010AE3

ASEA BROWN BOVERI 750191-001B NSFP 750191001B

ALSTOM ALSPA-MV-1013 USPP ALSPAMV1013

MICRO MOTION DL065-S242SU NSPP DL065S242SU

HUB CITY 88 NSFP 88

ALLEN BRADLEY 1774-KA USPP 1774KA

SIEMENS 6ES5-925-3SA11 USPP 6ES59253SA11

Siemens 6ES5-391-5AA13 USPP 6ES53915AA13

SIEMENS 6ES5 454-7LA11 6ES54547LA11

SIEMENS 6ES5 465-7LA13 Module

Siemens PLC 6ES5-451-4UA12/6ES54514UA12 Output

Siemens 6ES7 323-1BH01-0AA0 6ES7323-1BH01-0AA0 FreeShip

Siemens PLC 6ES7 338-4BC01-0AB0 6ES73384BC010AB0 NIB

PVDM3-32 CISCO 32-CHANNEL HIGH-DENSITY VOICE AND VIDEO DSP MODULE

GSM/GPRS Modem Pool 8 Ports USB interface Wavecom Module AT Commands Q2406

Unico 314-739 314739 Interface Module No Box

Siemens 6AV6 640-0DA11-0AX0 Touch Panel NIB

Siemens Logo 230RC 6ED1 052-1FB00-0BA3

MTT ms2304

Schneider Modicon Connector/Cable AS-W801-002/ASW801002

Schneider Modicon 800 SERIES AS-H827-103 11 PORT RACK ASH827103

Schneider Modicon AS-E685-904 NSFP ASE685904

Schneider Modicon Gould AS-B804-016 OUTPUT MODULE 16POINT 115VAC ANALOG

Schneider Modicon AS-B804-016

Schneider Modicon Output Module True High AS-B820-008

Schneider TWIDO TWDNOZ485T Expansion, Comm, RS485 Tbk

Schneider Modicon TSXPCX1031-C TSXPCX1031C PLC Cable

SiemensSimatic6AV6641-0CA01-0AX16AV66410CA01

Siemens 6AV6642-0BC01-1AX0 6AV6 642-0BC01-1AX0 SIMATIC TP177B 6" Touch Panel

SIEMENS S5 6DD2920-0AS0 INTERFACE MODULE PULSE CIRCUIT

GE Fanuc IC697RCM711C Redundancy Communications Module

SIEMENS Simodrive Part# 6SN1123-1AA00-0HA0 W/ Card

SIEMENS SINUMERIK 6FC5203-0AF02-0AA1

SIEMENS MOORE 750E111GNNNF ELECTRONIC PNEUMATIC VALVE POSITIONER AIR 750E 20113

Allen-Bradley Panel View 600 Plus

AB 1336E-B015-AA-EN 460V 15HP IMPACT DRIVE QUANTITY TESTED

ABB/ACS 500 150 HP Drive 440-500 VAC Cat# H502125400P2BBB200 3000

A06B-0332-B069#7000 FANUC SERVO MOTORS REMANUFACTURED

75 HP ELECTRIC MOTOR 1200 RPM 405T FRAME NEMA PREMIUM EFFICIENT SEVERE DUTY

RELIANCE ELECTRIC 6V41-096TA NSPP 6V41096TA

ALLEN BRADLEY 2711-K14C1 USPP 2711K14C1

ALLEN BRADLEY 1771-IF05 USPP 1771IF05

HONEYWELL 30731737-006 NSFP 30731737006

WESTINGHOUSE DBL-25-1200 USPP DBL251200

TEXAS INSTRUMENTS PLC VPU500-3104 USPP VPU5003104

GENERAL ELECTRIC DS3800DMEC1D1D USPP DS3800DMEC1D1D

Siemens 6ES5-188-3UA12 PLC Rack 21 Slot

SIEMENS 6ES5 375-0LC31 6ES53750LC31

SIEMENS 6ES5-988-3NA11 USPP 6ES59883NA11

Siemens 6ES5 930-8MD11/6ES5930-8MD11 POWER SUPPLY XLNT

Siemens 6ES5 944-7UB11 in Sealed Box

Siemens Micromaster 430 6SE6430-2UD31-8DA0 18.5KW

RELIANCE ELECTRIC 61C-350 USPP 61C350

Texas Instruments 500-2151

Spirent Adtech AX/4000 401381 L3 Gigabit MM Interface

VIA Artigo A2000 Barebones Storage Server 1.5 GHz VIA C7-D Brand

Siemens C98043-A1604-L3-03 no packaging

Modicon AS-W510-002

Schneider Modicon Automation AS-BDEP-216 Discrete Input -

Schneider Modicon AS-H819-209 CHASSIES ASH819209

Schneider Modicon AS-BDAP-112 USPP ASBDAP112

Schneider Modicon ASB872002 Excellent Analog OUT Module AS-B872-002

Schneider Modicon Automation Output Module DAP 210/AS-BDAP-210

Schneider Modicon AS-W801-006 ASW801006 Extender Cable NIB

Schneider Modicon 140CRA93100 / 140CRA 931 00

SCXI Accelerometer Input Modules NI SCXI-1531

RELEASE SuperMicro X9DRT-F MB ※Check W/ Us for Availability FIRST※

Siemens 6ES7 132-4BD00-0AA0 6ES71324BD000AA0 Output Module

SIEMENS SINUMERIK 840D/DE NCU 572.3 6FC5357-0BB22-0AE0

MODULE COMMUNICATION ALLEN BRADLEY 1203-GD1

SIEMENS SIMODRIVE 611 BOARD 6SN1118-0DJ21-0AA1NIB

SIEMENS SINUMERIK OP 010S 6FC5203-0AF04-0AA0 NIB

SIEMENS Caterpillar D6H / D6H Series II Tractors Service Manual 8KB 4RC 6FC

ALLEN-BRADLEY1756-OFCI/AOUTPUTMODULE1756-0FCI

Allen Bradley SLC 500 Output Module 1746-OX8 Ser. A

ABB ROBOT DSQC345B - RECTIFIER DC1 - 3HAB8101-2

A06B-0128-B575#7076 FANUC SERVO MOTORS REMANUFACTURED

0.1-1250 μm LPA-9Z Desktop Intelligent Laser Particle Size Analyzer Sizer

MODICON AS-M909-001 USPP ASM909001

ALLEN BRADLEY 1398-PDM-150B USPP 1398PDM150B

ADEPT TECH 10332-00500 USPP 1033200500

GE FANUC IC640WMI910 NSFP IC640WMI910

SIEMENS LMXD63B700 NSPP LMXD63B700

SIEMENS 6ES5-928-3UB12 USPP 6ES59283UB12

ALLEN BRADLEY 2755-DD1A-R1 NSFP 2755DD1AR1

Siemens 6ES5 928-3UB21 6ES59283UB21

Siemens SIMATIC 6ES5 926-3SA12

SIEMENS 6ES5-512-5BC12/6ES5512-5BC12 INTERFACE MODULE XLNT

Siemens 6ES5 441-4UA14/6ES54414UA14 Digital Input SEALED OFFERS ACCEPTED

SIEMENS 1FT6105-8SB71-1AA0 3-phase Brushless Servomotor

Siemens EM235 6ES7235-0KD00-0XA0 6ES72350KD000XA0

Schneider Digital Input Block Fuse 140CFB03200 3436

Square D 9006-PBF121

Siemens 6ES7460-0AA01-0AB0 SIMATIC S7-400 IM460-0 Transmitter Interface Module

WE SHIP SAME CISCO SLM2024T SG200-26 SLM2024T-NA 26PORT GIGABIT SMART

Siemens 6RA7018-6DV62-0-Z 6RA7018-6DV62-0 DC DRIVE

Siemens TP27-10 6AV3 627-1QL00-0AX0 Touch Glass, Bergquist Touch Products

Schneider Modicon TSX COMPACT DISCRETE OUTPUT AS-BDAP-210 4

Schneider Modicon ASBDAP210 AS-BDAP-210Compact output

Schneider Modicon AS-B825-016 NSFP ASB825016

Schneider Modicon MODULE AS-E908-131 S35D

Schneider Modicon AS-W192-015

Schneider Modicon AS-BZAE-204 HIGH SPEED COUNTER IN BOX FACTORY SEALED

SCHNEIDER TC2000 OPERATOR INTERFACE 3515 KPM PARTS/REPAIR BROKEN NOB

Siemens 6ES7 131-4BB00-0AA0 Digital Input Module 24 VDC /Un

RSP720-3CXL-GE Cisco Route Switch Processor 720-3CXL Router

Siemens Digital Output Module 6ES5 440-8MA22 TAKE-OUT

SIEMENS SINUMERIK 840C 6FC5103-0AE01-0AA1

Sammy AtomisWave Communication/Network Cartridge JAMMA PCB AW Module

SIEMENS 6SN1-162-0EB00-0AA0 NSPP 6SN11620EB000AA0

SIEMENS 6SC116111-2AA00-G600-D490/10-M6REQ SIMODRIVE

SIEMENS 6FC5-111-0CA02-0AA2 USPP 6FC51110CA020AA2

AllenBradley6182H-10TLH4DVersaViewCE1000HWorkstationPanel

Allen Bradley VersaView Display 17" to 19" Repair Service $169.99

ABB E2N-A16 600V 2000A PR121/P L/S/I INSULATED CASE CIRCUIT BREAKER

Adtech AX4000 LOADED WITH CARDS

(H13) 1 CUTLER-HAMMER LDB2600W SEALED BREAKER H13

KELLER TECHNOLOGY CORP 14449-5011 NSPP 144495011

ACUITY IMAGING 002-PV9040 USPP 002PV9040

FLUID POWER DIVISION PMC-20E USPP PMC20E

FANUC A06B-0143-B175 USPP A06B0143B175

SEIKO INSTRUMENTS & ELECS LTD OFL-760A-26 USPP OFL760A26

RAPID POWER TECH SPSAA100012 USPP SPSAA100012

RELIANCE ELECTRIC 86466-47T NSFP 8646647T

Siemens 6ES5 460-4UA13 -FS- 6ES54604UA13

Siemens 6ES5-928-3UA11 USPP 6ES59283UA11

SIEMENS 6ES5-430-7LA11 USPP 6ES54307LA11

Siemens 6ES5 490-7LB21 CONNECTOR IN BOX

Siemens S5 6ES5 464-8MC11

SIEMENS 802Dsl Membrane Keypad

SIEMENS 6ES7 223-1BL22-0XA8 EM 223 CN I/O MODULE

Square D 8005 MP-1

Nokia NIF4303FRU 2-Port X.21 PMC Interface Card Module

WS-F6K-DFC3A DIST FWD CARD-3A FOR 65XX 6816 MODULES WITH SUP720

SIEMENS 6ES7-151-1AA03-0AB0

Siemens SCD 1597-ET 6AV8100-1BB00-0AA0

Reliance 45C940

Schneider Modicon GOULD B805 AS-B805-016 INPUT MODULE 115 V AC

Schneider Modicon AS-B352-001 USPP ASB352001

Schneider Modicon AS-S908-021 USPP ASS908021

Schneider Modicon AS-B883-101

Schneider Modicon AS-B807-032 120VAC INPUT

MODICON AS-BDAP-210 DISCRETE OUTPUT MODULE

SIEMENS MODULE DIGITAL INPUT 505-4316A 5054316A

Siemens 6ES5 451-4UA13 -FS- 6ES54514UA13

Siemens PLC Output Module 6ES7 135-4FB01-0AB0 6ES71354FB010AB0 NIB